cefapirin Property

Melting point:

>135°C (dec.)

Boiling point:

783.9±60.0 °C(Predicted)

Density 

1.4021 (rough estimate)

refractive index 

1.6390 (estimate)

storage temp. 

-20°C Freezer, Under Inert Atmosphere

solubility 

≤10mg/ml in DMSO;5mg/ml in dimethyl formamide

form 

crystalline solid

pka

2.67±0.50(Predicted)

CAS DataBase Reference

21593-23-7

Safety

Hazardous Substances Data

21593-23-7(Hazardous Substances Data)

Hazard and Precautionary Statements (GHS)

Symbol(GHS)

Signal word

Danger

Hazard statements

H317May cause an allergic skin reaction

H334May cause allergy or asthma symptoms or breathing difficulties if inhaled

H351Suspected of causing cancer

Precautionary statements

P201Obtain special instructions before use.

P202Do not handle until all safety precautions have been read and understood.

P261Avoid breathing dust/fume/gas/mist/vapours/spray.

P272Contaminated work clothing should not be allowed out of the workplace.

P280Wear protective gloves/protective clothing/eye protection/face protection.

P281Use personal protective equipment as required.

P285In case of inadequate ventilation wear respiratory protection.

P302+P352IF ON SKIN: wash with plenty of soap and water.

P304+P341IF INHALED: If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing.

P308+P313IF exposed or concerned: Get medical advice/attention.

P321Specific treatment (see … on this label).

P333+P313IF SKIN irritation or rash occurs: Get medical advice/attention.

P342+P311IF experiencing respiratory symptoms: call a POISON CENTER or doctor/physician.

P363Wash contaminated clothing before reuse.

P405Store locked up.

P501Dispose of contents/container to..…

cefapirin Chemical Properties,Usage,Production

Chemical Properties

Beige Solid

Originator

Cefadyl,Bristol,US,1974

Uses

An antimicrobial agent.

Definition

ChEBI: Cephapirin is a cephalosporin with acetoxymethyl and 2(pyridin-4-ylsulfanyl)acetamido substituents at positions 3 and 7, respectively, of the cephem skeleton. It is used (as its sodium salt) as an antibiotic, being effective against gram-negative and gram-positive organisms. It has a role as an antibacterial drug. It is a conjugate acid of a cephapirin(1-).

Manufacturing Process

One route is that described in US Patent 3,422,100 as follows, starting with aminocephalosporanic acid (ACA): 27.2 g (0.1 mol) of 7-ACA, 33.2 g (0.3 mol) of NaHCO3, 200 ml of water and 100 ml of acetone were mixed together, cooled to 0°C and stirred rapidly while 20.1 g (0.1 mol) of bromoacetyl bromide dissolved in 100 ml of acetone was added in one fast addition. The temperature was kept at 0 to 5°C for ten minutes, then the ice-salt bath was removed and stirring continued for one hour as the temperature approached 25°C. The mixture was concentrated in vacuo at 20°C to one-half volume and 200 ml of water added. Two 400 ml ether extracts were made and discarded. The aqueous solution was covered with 200 ml of ethyl acetate and vigorously stirred and cooled while being acidified to pH 2 with 40% phosphoric acid.
The mixture was filtered, the ethyl acetate layer separated and washed with three 100 ml portions of water, dried over Na2SO4, filtered and treated with 30 ml of sodium 2-ethylhexanoate in n-butanol (34 ml = 0.1 mol). The oil which settled out was scratched to induce crystallization. After stirring for 20 minutes the product, sodium 7-(α-bromoacetamido)cephalosporanate, was scraped from the sides of the flask and collected. The filter cake was washed with several portions of acetone, air dried, and dried in vacuo over P2O5.The yield was 22.5 g and decomposed at 193°C.
A solution of 1.13 g (0.01 mol) of 2-mercaptopyrimidine and 1.06 g (0.01 mol) of sodium carbonate dissolved in 25 ml of water was added dropwise over a period of an hour at room temperature, to a stirred solution of 4.15 g (0.01 mol) of sodium 7-(α-bromoacetamido)cephalosporanate in 25 ml of water.
Stirring was continued an additional 90 minutes and then 50 ml of ethyl acetate was added, Forty percent H3PO4 was added dropwise with vigorous stirring until pH 2.5 to 3 was obtained. The product crystallized immediately and was filtered off, washed several times with water and then three times with 25 ml portions of ethyl acetate, following which it was air dried. The yield was 2.9 g of crystals that decomposed at 167 to 168°C. The IR and NMR spectra were consistent with the desired product, 7-[α-(2-pyrimidinylthio) acetamido]-cephalosporanic acid monohydrate.
An alternate route is that described in US Patent 3,503,967 which uses ACA in the last step.
Another alternative route is that described in US Patent 3,578,661 uses bromomethylcephalosporin as one raw material.
However the acid is prepared, the sodium salt may be prepared as described in US Patent 3,503,967: Five liters of methylene chloride were added to a clean dry vessel equipped with stirrer. 7-[α(4-pyridylthio)acetamido] cephalosporanic acid (1,000 g) was added to the vessel, followed by 350 ml of triethylamine. The resultant solution was treated with decolorizing charcoal for 15 minutes and filtered. A solution of sodium-3-ethyl-hexanoate (27.3%) in butanol-methylene chloride was added to the filtrate with stirring. Seven thousand five hundred milliliters of acetone was added. Crystallization occurred while stirring was continued several hours under dry conditions. The crystals were collected by filtration, washed with large volumes of acetone, and then dried in vacuo at 50°C to yield about 950 g of the title compound.

brand name

Cefadyl (Apothecon).

Therapeutic Function

Antibacterial

Biological Activity

cefapirin is the first generation cephalosporin antibiotic. cefapirin is broadly effective against gram-negative and gram-positive bacteria [1].the antibacterial action of cefapirin was due to the inhibition of cell-wall synthesis, mediated by its binding to penicillin binding proteins. it was mainly used in veterinary medicine for intramammary treatment of mastitis and intrauterine treatment of endometritis in cattle [1,2].cefapirin was an antibiotic particularly suitable for the treatment of acute otitis media. in 210 strains isolated from the auricular exudate of childrens' acute otitis media, the mic50 and mic90 of cefapirin were 2 and 4 mg/l for 112 strains of haemophilus. the mic ranged from 0.25 to 4 mg/l for ten strains of branhamella catarrhalis (9 secreted a beta-lactamase). cefapirin had an extremely high activity with mic50 and 90 less than 0.06 mg/l against streptococcus pneumoniae. for the strains of staphylococcus aureus sensitive to meticillin, one had a mic less than 0.06 mg/l, and 11 had a mic of 0.25 mg/l. for 14 strains of enterobacteriaceae studied, the mic 50 was 8 mg/l and the mic 90 was 32 mg/l [3].

Safety Profile

Moderately toxic by intraperitoneal route. Human systemic effects by intravenous route: jaundice. Experimental reproductive effects. When heated to decomposition it emits very toxic fumes of NOx and SOx.

References

[1] committee for veterinary medicinal products: cefapririn. emea, 1-6 (2001).
[2] ray, p. ,knowlton, k.f.,shang, c., et al. development and validation of a uplc-ms/ms method to monitor cephapirin excretion in dairy cows following intramammary infusion. plos one 9(11), 1-12 (2014).
[3] simonet m, herrmann j l, gehanno p, et al. activity of cefapirin against bacterial strains isolated from acute otitis media in children[j]. pathologie-biologie, 1990, 38(5): 352-354.